Engine compartment:
Body:
Cabin:
Still broken:
Job | Time | Cost |
| Car | — | 2000 |
| Acquisition | 3 | 20 |
| Reattached hood pad | 0.5 | 2 |
| Fuel pump diagnosis | 1 | — |
| Fuel pump relay repair | 2 | — |
| Topped off differential oil | 1 | 1 |
| Tax & License | — | 252.25 |
| Adjusted horse collar linkages | 1 | — |
| Fabricated hood bumper bolt | 1 | — |
| Clock repair | 2 | 1 |
| Repaired trunk lamp assembly | 2 | — |
| Added low-fuel-lamp test circuit | 1 | 0.50 |
| Resoldered blower controller | 1.5 | — |
| Repaired cruise control amplifier | 3 | 1 |
| Replaced missing cruise control connector shell | 1 | 2 |
| Resoldered ACC pushbutton panel | 2 | — |
| Replaced bad ACC and console lamps | 0.25 | 7 |
| Replaced missing ACC high-fan button | — | 2 |
| Touch-up paint | 3 | 3 |
| Center vent actuator diagnosis & repair | 3 | — |
| Replaced rotted ACC foam hose | 1 | 0.50 |
| Adjusted throttle linkage | 1 | — |
| Fabricated missing cruise control bracket | 1 | — |
| Resoldered idle controller | 1.5 | — |
| Checked monovalve | 1 | — |
| Replaced missing manifold heat shield screw | — | — |
| Cleaned idle speed actuator | 0.5 | 1 |
| Charged AC system | 1.5 | 7 |
| Corrected passenger-side head- and fog light wiring | 1 | — |
| Repaired broken clips (2) on fuse box cover | 0.5 | — |
| Tested cold-start valve | 1 | — |
| Replaced AC/fuel heat exchanger insulation | 0.25 | 1 |
| Replaced missing brake bleeder caps | 0.25 | 1 |
| Replaced missing AC valve caps | 0.25 | 1 |
| Replaced/repaired spark plug wire clips on valve covers | 0.25 | — |
| Reattached air dam | 0.5 | — |
| Repaired front license plate mount | 1.5 | — |
| Replaced missing fog light bolt | 0.25 | — |
| Adjusted headlights | 1 | — |
| Adjusted driver's door lock | 2 | — |
| Adjusted driver's window, seal repair | 2 | — |
| Replaced ignition module | 3 | 14 |
| Replaced missing coil cover | 1 | — |
| Replaced missing AC/fuel heat exchanger clamp | 1 | — |
| Repaired broken passenger door check | 1.5 | — |
| Replaced missing vent knobs | 0.5 | 3 |
| Replaced missing chrome hinge cover | 0.5 | — |
| Adjusted driver's door lock | 1.5 | — |
| Repaired passenger's door central locking mechanism | 1 | — |
| Rear seat belt | 2 | 6 |
| Reattached passenger window slide | 0.5 | — |
| CLA driver's window, etc. | 8.5 | 1.50 |
| Repaired door pockets | 2 | — |
| Removed surface rust inside soft top cover | 0.5 | — |
| Welded broken battery cover strap | 0.5 | — |
| Welded rusty trunk opening corner; surface rust treatment | 6 | — |
| Patched broken taillight lens | 1 | — |
| CLA passenger's window, etc. | 2.5 | — |
| Fabricated new passenger door lock knob | 2 | — |
| Grille derusting and repairs | 4 | — |
| Kickdown diagnosis | 0.5 | — |
| Refurbished console surround panel | 1 | — |
| Added auxiliary turn signal clacker | 1 | — |
| Repaired rear-window defroster | 4 | — |
| Repaired broken soft-top bolt | 2 | — |
| Ground squeaking high spot off back of steering wheel | 0.25 | — |
| Resoldered ACC temperature controller | 1 | — |
| Cleaned and lubricated driver's seat jack and track | 1.5 | — |
| Welded driver's seat back | 1 | — |
| CLA driver's seat back mechanism | 0.5 | — |
| Resoldered overvoltage protection relay | 1 | — |
| Bolstered spark wire insulation | 1 | — |
| Re-sealed windshield | 3 | 13 |
| New top turn-lock grommets | 0.25 | 6.50 |
| New ignition parts | 1 | 200 |
| Replaced defroster vacuum pod | 7 | 42 |
| Dash cap | 4 | 152 |
| Instrument cluster ground diagnosis | 1 | — |
| Glued firewall insulation | 1 | — |
| Repaired defroster flap and box | 1 | — |
| New hardtop grab-handle | 0.25 | 28.50 |
| Oil and filter | 1 | 24 |
| New valve stem seals on #7 | 2.5 | 19.05 |
| Alternator belt | 1.25 | 6.01 |
| Upper ball joints (2) | 6 | 65.60 |
| Resoldered warning module | 1 | — |
| Eliminated warning buzzer on right door operation | 1 | — |
| Re-glued loose LR coupe glass (leftover WS sealer) | 2 | — |
| Repaired brake wear sensor cables | 2 | — |
| New seat covers, with headrests | 10.25 | 494.20 |
| New chrome seat hinge covers | 1 | 220.88 |
| New (used) soft top | 1 | 205 |
| New sun visors | 1.5 | 200 |
| New steering idler bushing kit | 33.31 | |
| Tested compression and injectors | 2.5+ | — |
| Repaired cruise control cable | 0.25 | — |
| Adjusted shift linkage | 0.25 | — |
| Recharged AC | 1×2 | 8×2 |
| Warning module diagnosis, G102 cleaning | 1.5 | — |
| Re-glued softtop bay felt strips | 0.25 | — |
| Removed non-factory center brake light | 1.5 | — |
| Selective repaint | — | 300 |
| Tire well repairs | 1 | — |
| Resealed ZF power-steering pump | 3 | 17.10 |
| Windshield washer system repair | 2 | 3.58 |
| Replaced lost key | — | 23.19 |
| New valve stem seals on #7, again | 2 | — |
| Bypass restrictor on center vent pod | 1 | — |
| Extra-hot AP66 plug for #7 | 1 | 3 |
| Fixed squeaking trunk hinge pin | 17 | — |
| Repaired battery box and environs | 5 | — |
Totals: | Time | Cost |
| 188 Hours | $4400.67 |
